Product ID:MT TONER II, EP2100
MSDS Date:04/02/1993
FSC:6850
NIIN:00N026579
MSDS Number: BXQBN

MINOLTA CORP

101 WILLIAMS DR
RAMSEY, NJ 07446
US

Emergency Phone: 201-825-4000

Info Phone: 201-825-4000

Cage: GO339

MINOLTA CORPORATION

RAMSEY, NJ 07446 US

Telephone: 201-825-4000

Cage: 23736

STYRENE ACRYLATE COPOLYMER

CAS: 25153-46-2

Fraction By Weight: >80%

OSHA PEL N/K

ACGIH TLV: N/K

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: 5-10%

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

ORGANIC PIGMENT

CAS: 32517-36-5

Fraction By Weight: 1-5%

OSHA PEL N/K

ACGIH TLV: N/K

PROPENE POLYMERS; (POLYPROPYLENE)

CAS: 9003-07-0

RTECS: TR5000000

Fraction By Weight: 1-5%

OSHA PEL N/K

ACGIH TLV: N/K

SILICA GEL

CAS: 112945-52-5

RTECS: VV7310000

Fraction By Weight: <1%

OSHA PEL 6 MG/M3

ACGIH TLV: 10 MG/M3

LD50 LC50 Mixture:LD50:(ORAL,RAT) >5.0 G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:MINIMAL RESP TRACT IRRIT MAY
OCCUR AS W/EXPOS TO LG AMTS OF ANY NONTOX DUST. MAY CAUSE COUGH &
RAISE PHLEGM. TONER PRESENTS LOW HAZ FOR USUAL OCCUP SETTINGS.
BASED ON AVAIL DATA, HUMAN EXPOS TO TONER HAS BEEN SHOWN TO CAUSE
MINIMAL RESP TRACT IRRIT AS MAY OCCUR W/LG AMTS OF ANY NONTOX
DUSTS. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:RSLTS OF 1 ANIMAL STUDY WHERE RATS
INHALED TONER THAT WAS 10 TIMES MORE RESPIRABLE THAN COMMERCIALLY
AVAIL TONER WERE OBSERVED TO HAVE NO LUNG CHANGES @ LOW EXPOS (MOST
RELEVANT LEV TO POTNTL HUMAN EXPOS). AT HIGHER LEV SLIGHT DEGREE
OF LUNG FIBROSIS WAS OBSERVED DUE TO EXCESS AMTS OF DUST RETAINED
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL:WASH NOSTRILS, RINSE MOUTH. INGEST:DILUTE STOMACH
CONTENTS WITH SEVERAL GLASSES OF WATER. EYES:FLUSH WITH WATER FOR @
LEAST 15 MINUTES. SKIN:WASH WITH SOAP AND WATER.

Extinguishing Media:WATER, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:IF DISPERSED IN AIR, TONER, LIKE MOST
FINELY DIVIDED ORGANIC POWDERS, MAY FORM AN EXPLOSIVE MIXTURE.

Spill Release Procedures:SWEEP UP OR VACUUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:NONE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:NONE REQUIRED. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Protective Gloves:NONE REQUIRED.
Eye Protection:ANSI APPROVED SAFETY GLASSES .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:IN THE LUNGS FOR PROLONGED INTERVAL. CHRONIC:NONE
LISTED BY MANUFACTURER.

Spec Gravity:1.15 (H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER, FAINT ODOR.

Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION ARE TOXIC.
AVOID BREATHING OF SMOKE.

Waste Disposal Methods:WASTE MAY BE DISPOSED OR INCINERATED UNDER
CONDITIONS WHICH MEET ALL FEDERAL, STATE AND LOCAL ENVIRONMENTAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.